行业新闻

当前位置:首页 > 新闻中心 > 行业新闻 >

如何提高制氮机的使用寿命?

来源:https://www.sdqyjn.com/   日期:2020-08-12   浏览量:
TAG:山东制氮机,山东干燥机,山东螺杆鼓风机,山东空压机,山东自动排水器

保养对于任何机器而言都是非常重要的,可以有效延长制氮机的使用寿命。那么如何提高制氮机的使用寿命,下面山东制氮机的小编为大家介绍下:

Maintenance is very important for any machine, which can effectively extend the service life of nitrogen generator. So how to improve the service life of the nitrogen generator, the following small edition of Shandong nitrogen generator is introduced for you:

除了保养之外,正确使用制氮机对于延长机器设备也是至关重要的。

In addition to maintenance, the correct use of nitrogen generator is also essential for the extension of machinery and equipment.

1、关闭所有的电源开关,包括制氮机和氮气入口阀及取样阀,等待系统和管道完全泄压结束。调节氧分析仪进行取样并将减压阀压力调节到1.0bar,调节取样流量计,将气量调至在1左右即可,注意采样气量不宜过大,开始检测氮气纯度。


20171218111431120.jpg

1. Turn off all power switches, including nitrogen generator, nitrogen inlet valve and sampling valve, and wait for complete pressure relief of system and pipeline. Adjust the oxygen analyzer for sampling, adjust the pressure of the pressure reducing valve to 1.0 bar, adjust the sampling flowmeter to adjust the gas volume to about 1. Pay attention to the sampling gas volume should not be too large, and start to detect the purity of nitrogen.

2、在压缩空气压力要达到0.7mpa以上之后,才能打开制氮机的截止阀,同时要注意观察吸附罐的压力变化情况和气动阀的工作能否正常进行。

2. The stop valve of nitrogen generator can only be opened after the compressed air pressure reaches above 0.7MPa. At the same time, the pressure change of adsorption tank and the normal operation of pneumatic valve should be observed.

3、再生塔压力为零,均匀时两塔压力应接近原工作塔压力的一半。

3. When the pressure of regeneration tower is zero, the pressure of two towers should be close to half of the original working tower pressure.

4、关闭整个系统和系统各部分,在制氮机吸附罐压力达到0.6MPa左右时,观察制氮系统是否正常工作。

4. Close the whole system and all parts of the system, and observe whether the nitrogen generation system works normally when the pressure of adsorption tank of nitrogen generator reaches about 0.6MPa.

在阅读的小编为大家介绍的如何保持制氮机的相关内容之后,是否已经有所了解,想要更多的相关内容,可关注我们公司网站:https://www.sdqyjn.com/后期会呈现更多的精彩内容。

After reading the introduction of how to maintain the relevant content of nitrogen generator, whether you have any understanding. For more relevant content, please pay attention to our website: https://www.sdqyjn.com/ More wonderful content will be presented later.


上一篇:第一页
下一篇:山东空压机高温停机的原因是什么?