行业新闻

当前位置:首页 > 新闻中心 > 行业新闻

自动排水器的保养措施是什么?

来源:https://www.sdqyjn.com/   日期:2021-01-22   浏览量:0
TAG:山东制氮机,山东干燥机,山东螺杆鼓风机,山东空压机,山东自动排水器

自动排水器在使用过程中,可能会出现电磁阀关闭不严的情况,表现为一直漏气。通常,该故障并非排水器本身质量所致,其原因是冷凝水太脏,水中的微小固体颗粒物进入阀芯与护套之间的间隙,将阀芯卡住。

In the process of using the automatic drainer, the solenoid valve may not be closed tightly, which shows that there is always air leakage. Usually, the fault is not caused by the quality of the drain itself, the reason is that the condensate water is too dirty, and the small solid particles in the water enter the gap between the valve core and the sheath, and the valve core is stuck.

20210122312147.jpg

出现此故障可用如下方法排除:

This fault can be eliminated by the following methods:

1.反复多次按测试(TEST)按钮直至故障排除(此方法对轻微的阀芯卡住极为有效)。

1. Repeatedly press the test button until the fault is eliminated (this method is very effective for slight valve core sticking).

2.如以上方法不能奏效,则需拆开电磁阀,清洗阀芯:

2. If the above methods do not work, disassemble the solenoid valve and clean the valve core

(1)关闭过滤器,按测试(TEST)按钮,确保电子自动排水器与空压系统隔离(在零压力下);

(1) Close the filter and press the test button to ensure that the electronic automatic drainer is isolated from the air pressure system (under zero pressure);

(2)切断电子自动排水器电源;

(2) Cut off the power supply of the electronic automatic drainer;

(3)松开并取下连接线圈、控制器、接线头的长螺钉;

(3) Loosen and remove the long screws connecting the coil, controller and connector;

3、按下列顺序分解、清洁及反向组合:

3. Decompose, clean and reverse combination in the following order:

A:切断排水器入口空气;

A: Cut off the inlet air of the drainer;

B:松开减压螺丝放气;

B: Loosen the pressure reducing screw to release air;

C:确认排水器内无压力卸下连接螺套;

C: Confirm that there is no pressure in the drainer and remove the connecting screw sleeve;

D:卸下粗滤网滤网固定螺母;

D: Remove the fixing nut of coarse filter screen;

E:反时针旋下排水导管、水杯、浮球、排水导管分解并取下细滤网;

E: Turn the drain pipe, water cup, floating ball and drain pipe anticlockwise to disassemble and remove the fine filter screen;

F:卸下控制杆取出阀及浮子;

F: Remove the control rod, take out the valve and float;

G:用双手各握腔体与排水管小心往90度角用力使其分开,取出弹簧和精滤网及泄气薄片;

G: Hold the cavity and drain pipe with both hands, carefully separate them at a 90 degree angle, and take out the spring, fine filter screen and vent sheet;

H:用中性洗剂彻底清除污渍,按相反次序组合正常使用。

H: Use neutral lotion to remove stains completely, and use them in reverse order.

以上就是小编为大家介绍的关于 自动排水器的日常维护的解决方法,希望可以帮助到您,更多的精彩内容关注我们!

The above is Xiaobian for you to introduce the solution of the daily maintenance of automatic drainer, hope to help you, more wonderful content, pay attention to us!


上一篇:自动排水器出现积水的三种解决方法
下一篇:影响沸腾干燥机干燥效果的四个因素及设备特点