怎样判断制氮机的运行状况良好

判断制氮机在运行当中是否良好，可以根据下面的露点来分析。灵活应用，如果还是有疑问，可以联系制氮机厂家技术人员查看。

Judging whether the nitrogen generator is in good operation can be analyzed according to the following dew point. Flexible application, if you still have questions, you can contact the technical personnel of the nitrogen generator manufacturer to check.

1、电源指示灯亮，左吸、均压、右吸指示灯循环发亮指示制氮流程。

1. The power indicator light is on, and the indicator lights of left suction, voltage equalizing and right suction are on circularly to indicate the process of nitrogen production.

2、左吸指示灯亮时，左吸附塔压力由均压时平衡压力逐渐升至最高，制氮机同时右吸附塔压力由均压时平衡压力逐渐降为零。均压指示灯亮时，左右吸附塔压力降一升一降逐渐达到两者平衡。

2. When the left suction indicator light is on, the pressure of the left adsorption tower gradually rises to the highest value from the equilibrium pressure during pressure equalization, and the pressure of the right adsorption tower of the nitrogen generator gradually drops to zero from the equilibrium pressure when the pressure is equalized. When the pressure equalizing indicator light is on, the pressure drop of the left and right adsorption towers increases and decreases gradually to reach the balance between the two.

3、右吸指示灯亮时，右吸附塔压力由均压时平衡压力逐渐升至最高，同时左吸附塔压力由均压时平衡压力逐渐降为零。

3. When the indicator light of the right adsorption tower is on, the pressure of the right adsorption tower gradually rises to the highest value from the equilibrium pressure during the pressure equalization, and the pressure of the left adsorption tower gradually drops to zero from the equilibrium pressure when the pressure is equalized.

4、制氮机氮气出口压力指示为正常用气压力，使用时压力会有稍微波动，但变化不应过大。

4. The nitrogen outlet pressure of the nitrogen generator is indicated as the normal gas pressure. The pressure will fluctuate slightly during use, but the change should not be too large.

5、力量计指示应基本稳定，波动不应过大，流量计的示值不应大于制氮机设备的额定产气量。

5. The indication of the dynamometer should be basically stable and the fluctuation should not be too large. The indication value of the flowmeter should not be greater than the rated gas production of the nitrogen generator.

6、制氮机测氧仪示值应不小于制氮设备的额定纯度，也许会有少许波动，但不应波动过大。

6. The indication value of oxygen meter of nitrogen generator should not be less than the rated purity of nitrogen generating equipment. There may be a little fluctuation, but it should not be too large.

这些事为了告诉大家制氮机运行状态良好的几个特状，对于使用方来说，山东制氮机建议可以联系厂家技术人员查看。

In order to tell you the characteristics of the nitrogen generator running well, for the user, Shandong nitrogen generator can contact the manufacturer's technical personnel to check.