自动排水器的如何进行工作的？

自动排水器用在自动排除管道低处、油水分离器、气罐及各种过滤器底部等处的冷凝水。可安装在人工排污水不便的地方，因人工排水常常会遗忘，造成压缩空气被冷凝水污染。

The automatic drainer is used to automatically drain the condensed water at the lower part of the pipeline, the oil-water separator, the air tank and the bottom of various filters. It can be installed in the place where it is inconvenient to discharge the sewage manually. Because of the artificial drainage, the compressed air is often polluted by condensed water.

自动排水器是利用空压系统里的空气压，经由一条导管连接，其顶端的泄压阀能调整微量排气，让排水器的压力低于空压系统，可将冷凝水、油泥和锈渣推挤远离空压系统。

The automatic drainer uses the air pressure in the air pressure system and is connected through a pipe. The pressure relief valve at the top of the automatic drainer can adjust the micro exhaust, so that the pressure of the drainer is lower than that of the air pressure system, and can push the condensate, oil sludge and rust residue away from the air pressure system.

山东自动排水器

Shandong automatic drainer

它有电子的和物理的，电子排水器的原理是电磁阀控制阀门的开和关，可以通过设置上面的开关调节自动排水开启的时间和周期；物理的排水器就是靠排水器里的浮标的浮力来开启排水器。排水器里的液面上升，浮标上升，阀门就自动开启了。

It has electronic and physical. The principle of electronic drainer is that the solenoid valve controls the opening and closing of the valve, and the opening time and cycle of automatic drainage can be adjusted by setting the switch above; the physical drainer is to open the drainer by the buoyancy of the buoy in the drainer. When the liquid level in the drain rises, the buoy rises and the valve opens automatically.

把这些水分与杂质连续挤压后，输入积存在自动排水器的下方，再由浮球升高来打开上方的控制器之阀门，再定量自动排放与关闭，这种装置可有效的保持空压系统洁净，而且安装时可不受高度与距离的限制，可随意安装在理想位置，它更不需要使用电源或其他控制导管即可灵活而精准的排放水分与污垢。

After the moisture and impurities are continuously extruded, the input product is stored under the automatic drainer, and then the valve of the upper controller is opened by the floating ball, and then the quantitative automatic discharge and closing can be realized. This device can effectively keep the air pressure system clean, and can be installed in the ideal position without the limitation of height and distance when installing, and it does not need to use power supply or other controls The tube can discharge water and dirt flexibly and accurately.   

自动排水器的另一特殊设计结构，即气体、液体、固体三态三层分离结构可使控制器免于浸泡在油污与水分中，这些污水等流体不经过控制器，此控制器的气体通路有三重的过滤装置，不会使控制通路阻塞及损坏零件，在使用长久时间后，仍可有效灵活控制而不故障。

Another special design structure of automatic drainer, i.e. gas, liquid and solid three-layer separation structure, can prevent the controller from being immersed in oil and water. These sewage and other fluids do not pass through the controller. The gas path of the controller has a triple filtering device, which will not block the control channel and damage the parts. After a long time of use, it can still be effectively and flexibly controlled Obstacles.